Best 8 Grilled Cheese Bun Burgers Recipes

GRILLED CHEESE-STUFFED BURGERS

Steps:

• 1. Preheat a grill over high heat. Divide the meat into four 6-ounce balls. Press 4 small cubes of cheese into the center of each ball and flatten into a 1/2-inch-thick patty about 4 inches in diameter, making sure the cheese stays wrapped in the meat. Sprinkle both sides of the patties evenly with 1 teaspoon salt and 1/2 teaspoon pepper. Wrap each burger in a piece of nonstick aluminum foil, twisting any excess foil at each end so the burger is wrapped in a single layer of foil only. Mix the ketchup and Worcestershire together in a small bowl.
• 2. Grill the burgers for 5 minutes per side. Remove from the grill and carefully open up the foil packets, allowing the steam to escape. Place the opened foil packets back on the grill, add a spoonful of sauce to the top of each patty and continue to cook until the patty is cooked to at least medium to allow the cheese inside to fully melt, another 4 to 6 minutes.
• 3. On the bottom half of each bun, spread a bit of sauce and top with a lettuce leaf, onion slice and tomato slice. Top with a patty, another spoon of the remaining sauce and the top of the bun. Serve with chips or fries.

"GRILLED CHEESE" BURGERS

Steps:

• Preheat oven to 350°. Spread butter evenly on one side of each piece of bread, then place bread buttered side down in a cast-iron skillet over medium-high heat until golden brown. Transfer to a large sheet pan with toasted side down and place 2 pieces of American cheese on each piece of bread.
• Preheat same cast iron pan over high heat. In a mixing bowl, add cold ground beef and season with salt and pepper. Divide into 1/4-lb. burgers and form 1/2"-thick, square-shaped patties, similar to bread dimensions. (Avoid over-handling burgers as it will make them tough.) Cook burgers in two batches; flip burger after 2 minutes, then cook 2 minutes more. Transfer to a plate and loosely cover with aluminum foil; rest 2 minutes.
• Meanwhile, place sheet pan with bread in the oven until cheese is just melted. Lightly blot burgers with a paper towel, then place burgers on toasted bread with cheese and top with second piece of bread.
• Return grilled cheese burgers to the cast iron pan to warm the bread. Serve immediately, with ketchup.

GRILLED CHEESE BUN BURGERS

Steps:

• In a large bowl, combine beef, Worcestershire sauce, garlic powder, salt, pepper and liquid smoke if desired, mixing lightly but thoroughly. Shape into four 4-in. square patties., In a large nonstick skillet, cook burgers in oil over medium heat until a thermometer reads 160°, 4-5 minutes on each side. Remove and keep warm., In the same skillet, heat 1 tablespoon butter over medium-high heat. Add onion; cook and stir until tender, 6-8 minutes. Remove and keep warm. Place cheese on 8 bread slices; top with remaining bread. Spread outsides of sandwiches with remaining 4 tablespoons butter. , In the same skillet, toast sandwiches over medium heat until golden brown and cheese is melted, 1-2 minutes on each side. Top 4 sandwiches with burgers and onions. Top with remaining sandwiches.

MY MOST COVETED SECRET: HERB-GARLIC BUTTER HAMBURGERS ON A GRILL

Steps:

• Place all the herbs, garlic, pepper, and butter in a small mixing bowl and beat with a wooden spoon until slightly fluffy.
• (you can do the mixing with a or food processor) Place a 12" square piece of plastic wrap or parchment paper on your work surface and mound the flavored butter in the center.
• Roll herb butter into cylinder shape within plastic, twisting the ends to compress the butter.
• Chill the butter in the refrigerator or freeze until firm.
• Butter will keep for up to 5 days in the refrigerator or up to 3 months in the freezer.
• Burger Preparation: Make hamburger patties as usual, but for each one place your thumb in the middle and press an indentation almost through (but not quite) to the other side of the meat.
• Unwrap formed butter and cut crosswise into 1/4-1/2" discs. (You will be using approximately 4 tablespoons Herb-Garlic Butter per 1 1/2 pound of ground meat).
• Form hamburger patty fully around one butter disc, pressing gently to seal the disc into the dead center of the meat.
• (not too much pressing! It will make your burgers dense and tough) Place burgers on hot grill (preheated to high if using a gas grill).
• Grill burgers until cooked to doneness, (about 5 to 7 minutes per side for medium-done).
• Place burgers on a serving plate, add cheese, if desired, but do not serve for about 5 minutes, to allow flavors to fully meld.
• Brush buns with melted butter and toast on the grill for a few seconds.
• Serve with any toppings of your choice.

GRILLED CHEESE BUNS

Steps:

• Spread just enough butter to cover both sides of each slice of bread.
• In a large nonstick pan set over medium heat, add the bread slices and cook until they're an even golden brown on the first side, about 2 minutes. Flip 2 of the slices over and top each with 2 slices of the cheese. Place the other 2 slices of bread on top, toasted-side down, forming 2 sandwiches. Continue to cook the sandwiches until the bottoms are golden brown, about 2 minutes. Flip and cook the remaining side for an additional 2 minutes.

GRILLED STUFFED CHEESEBURGER BUNS

Steps:

• Whisk the ketchup, mayonnaise, pickles and mustard in a small bowl until well combined. Cover and refrigerate until ready to serve.
• Mix the ground beef, American cheese, red onion, 1 teaspoon salt and a few grinds of pepper in a medium bowl until well combined. Form the mixture into 8 small patties, each about 1 ounce and 2 inches in diameter.
• Divide the pizza dough into eight 2-ounce pieces. Working with one piece at a time, press the dough into a 4-inch round and place 1 cheeseburger patty into the center. Fold the edges of the dough over the patty, pinching it together in the center tightly so that the patty is completely covered and there is no gap for any cheese to spill out when cooking. Repeat with the remaining dough and patties. Refrigerate, covered, until ready to grill, up to 1 day.
• Place a 12-inch cast-iron skillet onto the grill and prepare the grill for medium heat (about 350 degrees F).
• Once preheated turn the burner underneath the skillet off. Brush the tops of the buns with the olive oil and sprinkle with the sesame seeds. Place the buns into the heated cast-iron skillet, spacing them apart so none of them are touching. Cover the grill and cook, using grilling tongs to pick up and reposition the buns occasionally so they don't burn on the bottom, until the buns are golden brown and cooked through, 20 to 25 minutes. Let the buns cool for at least 15 minutes before serving with the special sauce on the side.

GRILLED BURGERS

Steps:

• In a large bowl, combine the first 5 ingredients; add beef and mix gently. Shape into 10 patties. , Grill, uncovered, over medium heat for 4-5 minutes on each side or until meat is no longer pink. Serve on buns with desired toppings.

GRILLED TURKEY BURGERS

Steps:

• Heat the grill to medium-high. Lightly grease a plate and set aside. Coarsely grate 1/4 cup onion; reserve the remaining onion. In a medium bowl, mix the turkey, grated onion and 2 tablespoons barbecue sauce. Form 4 patties about 4 ½ inches wide (about 5 ounces each). Press a small dimple in the center of each patty, then place the burgers on the plate and refrigerate until firm (at least 5 minutes or, covered, up to 2 days).
• Meanwhile, in a small bowl, stir together the remaining 2 tablespoons barbecue sauce with the mayonnaise; season with 1 teaspoon each of salt and pepper.
• When ready to grill, dip the reserved onion in oil. Clean the grates with a grill brush, then grease the grates with the oiled onion. (This perfumes the grill and your patties.) Lightly coat the tops of the burgers with some of the mayo mixture (about 1/2 teaspoon per patty).
• Grill the burgers, mayo side down, until well browned and patties release from the grates, 4 to 6 minutes. (If flare-ups occur, move to an area of the grill where there are no flames underneath. For a gas grill, close the lid between flips, listening and keeping an eye out for flare-ups.) Spread mayo mixture on the tops of the patties, then flip and grill on the second side until cooked through, another 4 to 6 minutes.
• Transfer to a plate and let rest for at least 5 minutes. Grill the cut sides of the buns until toasted, 1 to 2 minutes. Build burgers on the buns with the patties and desired toppings and condiments.