Best 8 North Carolina Pulled Pork Sandwich Recipes

NORTH CAROLINA-STYLE PULLED PORK

Steps:

• In a small bowl, mix mild paprika, light brown sugar, hot paprika, celery salt, garlic salt, dry mustard, ground black pepper, onion powder, and salt. Rub spice mixture into the roast on all sides. Wrap in plastic wrap, and refrigerate 8 hours, or overnight.
• Prepare a grill for indirect heat.
• Sprinkle a handful of soaked wood over coals, or place in the smoker box of a gas grill. Place pork butt roast on the grate over a drip pan. Cover grill, and cook pork until pork is tender and shreds easily, about 6 hours. Check hourly, adding fresh coals and hickory chips as necessary to maintain heat and smoke.
• Remove pork from heat and place on a cutting board. Allow the meat to cool approximately 15 minutes, then shred into bite-sized pieces using two forks. This requires patience.
• In a medium bowl, whisk together cider vinegar, water, ketchup, brown sugar, salt, red pepper flakes, black pepper, and white pepper. Continue whisking until brown sugar and salt have dissolved. Place shredded pork and vinegar sauce in a large roasting pan, and stir to coat pork. Serve immediately, or cover and keep warm on the grill for up to one hour until serving.

NORTH CAROLINA PULLED-PORK BARBECUE

Steps:

• Bring vinegar to a boil with sugar, red-pepper flakes, 2 tsp salt, and 1 Tbsp pepper in a small nonreactive saucepan, stirring until sugar has dissolved, then cool. Set aside 2 cups vinegar sauce to serve with sandwiches.
• While sauce cools, score pork skin in a crosshatch pattern with a sharp knife (forming 1-inch diamonds), cutting through skin and fat but not into meat. Pat meat dry and rub all over with 1 Tbsp each of salt and pepper. Let stand at room temperature 1 hour before grilling.
• Prepare grill for indirect-heat cooking over low heat, leaving space in middle for disposable roasting pan.
• When coals have cooled to about 300°F (45 minutes to 1 hour; when most coals will have burned out), put disposable roasting pan on bottom rack of grill between the 2 remaining mounds of coals, then fill pan halfway with water. Add a couple of handfuls of unlit charcoal to each charcoal mound, then put grill rack on so hinges are over coals.
• Oil grill rack, then put pork, skin side up, on rack above roasting pan. Grill pork, with lid ajar (for air, so coals remain lit), basting meat with sauce and turning over every 30 minutes (to maintain a temperature of 250 to 275°F, add a couple of handfuls of coals to each side about every 30 minutes), until fork-tender (a meat fork should insert easily) and an instant-read thermometer inserted 2 inches into center of meat (avoid bone) registers 190°F, 7 to 8 hours total.
• Transfer pork to a cutting board. If skin is not crisp, cut it off with at least 1/4 inch fat attached (cut any large pieces into bite-size ones) and roast, fat side down, in a 4-sided sheet pan in a 350°F oven until crisp, 15 to 20 minutes.
• When meat is cool enough to handle, shred it using 2 forks. Transfer to a bowl.
• Serve pork, cracklings, and coleslaw together on buns. Serve reserved vinegar sauce on the side.

NORTH CAROLINA-STYLE PULLED PORK

Steps:

• Preheat a grill to medium low and prepare for indirect cooking: On a gas grill, preheat the grill, then turn off the center burners. On a charcoal grill, light the coals, then push to the edges of the grill, creating an open space in the middle; put a disposable aluminum drip pan in the middle of the grill under the grates.
• When the grill registers 250˚ F, place the pork on the grill grates over the cooler part. Cover the grill and cook the pork until the skin is crisp, the meat easily falls off the bone and a thermometer inserted into the center of the pork (away from the bone) registers 190˚ F to 200˚ F, 7 to 10 hours (if using charcoal, adjust the air vents and add more coals as needed so the temperature stays around 250˚ F).
• Meanwhile, make the barbecue sauce: Combine 1 cup water, the vinegar, hot sauce, sugar, red pepper flakes, 2 1/2 tablespoons salt and 2 teaspoons black pepper in a pot. Bring to a boil over medium-high heat, stirring occasionally, until the sugar and salt dissolve. Let cool.
• If using a gas grill, turn off the heat and carefully transfer the pork to a cutting board. If using a charcoal grill, do this quickly, as the grease may cause the coals to catch fire. Let the pork rest at least 30 minutes, then pull the meat off the bone with tongs and a large fork; discard the bones and any large pieces of fat. Chop the crispy skin and stir into the meat. Transfer to a bowl and toss with 1 to 2 cups of the barbecue sauce. Serve on buns with the remaining sauce.

CAROLINA STYLE PULLED PORK SANDWICH

Steps:

• The Meat --.
• Place the quartered onions in a crock pot.
• Combine brown sugar, paprika, salt and pepper: rub over the roast.
• Place the roast over the onions in the crock pot.
• Combine the vinegar, Worcestershire Sauce, red pepper flakes, sugar, mustard, garlic salt and cayenne; stir to mix well.
• Drizzle about 1/2 of the vinegar mixture over the roast and cover. Refrigerate the remaining vinegar mixture.
• Cook on low for 8 hours. Drizzle the other half of the vinegar mixture over the roast during the last 1/2 hour of cooking.
• While the meat is cooking, prepare the barbecue sauce. Mix all ingredients except soy sauce, butter and smoke. Simmer, uncovered, on low heat for 30 minutes. Stir in the remaining ingredients and simmer, uncovered, for 10 more minutes. Set aside to cool.
• Remove the meat from the crock pot and allow to rest for at least 15 minutes. (Very important step -- longer is better).
• Remove the onions and chop to a fine consistency.
• Pull apart the meat with a couple of forks. Meat should have a shredded look to it.
• Mix chopped onions and shredded pork along with a little bit of juice from the crock pot to taste. Add sufficient barbecue sauce to the mixture to achieve desired taste. Meat should have distinctive barbecue flavor.
• To serve, spread barbecue sauce on bottom of a hearty bun.
• Put layer of pulled pork on bun. Spread barbecue sauce over meat.
• Add layer of your favorite cole slaw on top of meat. Layer some more barbecue sauce over cole slaw.
• Spread top of bun with more sauce.
• Grab a fist full of napkins, and enjoy.

NORTH CAROLINA-STYLE PULLED PORK SANDWICHES AND COLESLAW

Steps:

• Preheat the oven to 300 degrees. Mix together the salt, pepper, and paprika; sprinkle all over the pork and rub inches
• In a large skillet or Dutch oven, heat the oil over medium-high heat. Add the pork and cook, turning occasionally, until browned, 8 to 10 minutes. Transfer to a 24-inch-long sheet of heavy duty foil and double wrap the pork.
• Place the pork, skin side up, in a 9-by-13-inch baking dish; roast until tender, about 4 1/2 hours. Remove from the oven and carefully unwrap the top of the pork, revealing the skin. Increase the heat to 450 degrees and roast for 20 minutes more.
• Transfer the roast to a large bowl, along with any juices. Using two forks, shred the pork. Add the vinegars, sugar, and hot sauce; toss. Serve on the hamburger buns, topped with coleslaw (recipe follows), if using.
• For the coleslaw: In a medium bowl, whisk together the vinegars, sugar, hot sauce, crushed red pepper, salt, and pepper. Add the cabbage and toss. Let stand for 30 minutes, then toss and serve.

NORTH CAROLINA-STYLE BBQ PULLED-PORK SANDWICHES

Steps:

• Make small holes all over the pork shoulder with a thin sharp knife and stuff in garlic cloves. Rub the meat all over with the Memphis Shake; cover and refrigerate overnight.
• Prepare an outdoor grill with an indirect medium-hot fire with a mix of briquettes and hardwood charcoal in half of the grill. Set grate over coals. Place pork, skin side up, in an aluminum pan with about 1 1/2 cups water on the cooler side of the grate. Toss 1 cup of the soaked and drained wood chips onto the coals and cover the grill, making sure the lid's vents are directly over pork.
• When the coals cool to medium-low heat, preheat a chimney-full of hot briquettes and hardwood charcoal. Whenever smoke stops coming out of the vents, about every hour, add more hot coals and 1 cup of soaked and drained wood chips to the fire. The goal is to maintain a medium-heat, smoky fire (but don't worry if it is hotter when the coals are added and cooler while preheating the coals). Rotate the pork when you add coals so it cooks evenly. Cook the meat until an instant-read thermometer inserted into the thickest part of the pork registers 180 degrees F, about 6 hours.
• Set aside 1 quart of the North Carolina-Style Vinegar BBQ Sauce. Once the pork reaches 180 degrees F, begin mopping the entire surface of the meat every 20 minutes with some of the remaining sauce and the pan drippings. Continue to cook the pork, covering the grill between mopping, until an instant-read thermometer registers 200 degrees F, about 1 to 2 hours more.
• Transfer the pork to a cutting board and let rest for at least 15 minutes. Remove the outer skin and discard. Cut large chunks from the bone and shred, using 2 forks or your fingers, (when cool enough to touch) or chop. Toss with about 1 cup of the reserved barbecue sauce for every 3 cups of meat. Tuck the pork into the soft rolls and serve with pickles.
• Whisk paprika, brown sugar, oregano, garlic, ancho powder, salt, and celery salt in a small bowl. Store in an airtight container in a cool, dry place for up to 2 months.
• Heat the vinegar and sugar in a medium saucepan over medium heat until the sugar dissolves. Off the heat, stir in the ketchup, honey, salt, red pepper, and black pepper.

NORTH CAROLINA PULLED PORK

Steps:

• Preheat slow cooker on Low for 15 minutes.
• Season pork shoulder with salt and pepper; place pork in preheated slow cooker. Mix ketchup, brown sugar, and vinegar in a bowl; pour over pork.
• Cook on Low for 8 hours. Transfer pork to a large platter and slice into 3 to 4 pieces. Shred meat with 2 forks and return to slow cooker. Continue to cook for 1 hour.

CAROLINA PULLED-PORK SANDWICHES

Steps:

• Make dry rub:
• Mix first 5 ingredients in small bowl to blend.
• Place pork, fat side up, on work surface. Cut each piece lengthwise in half. Place on large baking sheet. Sprinkle dry rub all over pork; press into pork. Cover with plastic; refrigerate at least 2 hours. (Can be made 1 day ahead. Keep chilled.)
• Make mop:
• Mix first 6 ingredients in medium bowl. Cover and refrigerate.
• Following manufacturer's instructions and using lump charcoal and 1/2 cup drained wood chips for smoker or 1 cup for barbecue, start fire and bring temperature of smoker or barbecue to 225°F. to 250°F. Place pork on rack in smoker or barbecue. Cover; cook until meat thermometer inserted into center of pork registers 165°F., turning pork and brushing with cold mop every 45 minutes, about 6 hours total. Add more charcoal as needed to maintain 225°F. to 250°F. temperature and more drained wood chips (1/2 cup for smoker or 1 cup for barbecue with each addition) to maintain smoke level.
• Transfer pork to clean rimmed baking sheet. Let stand until cool enough to handle. Shred into bite-size pieces. Mound on platter. Pour any juices from sheet over pork. (Can be made 1 day ahead. Transfer pork and any juices to baking dish. Cover with foil; chill. Before continuing, rewarm pork, covered, in 350°°F. oven about 30 minutes.)
• Divide pork among bottoms of buns. Drizzle lightly with barbecue sauce. Top with coleslaw. Cover with tops of buns.